Productsleaching of roasted copper sulfide ore

BF Flotation Cell

BF flotation cell has two types: type I and type II. Type I is improved as suction cell referring to model SF; type II is improved as direct flow cell referring to model JJF.

more+

Cyclone Unit

Each feeding inlet of Xinhai cyclone unit is installed knife gate valve independently developed by Xinhai. This valve with small dimension reduces the diameter of cyclone unit.

more+

Hydraulic Cone Crusher

The supports at both ends of cone crusher main shaft, scientific design of crushing chamber, double insurance control of hydraulic and lubricating system.

more+

Overflow Type Ball Mill

Wet type overflow ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance, long service life and convenient maintenance

more+

Grid Type Ball Mill

Wet type grid ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance design, long service life and convenient maintenance.

more+

Round Vibrating Screen(YA)

Ring groove rivets connection, plate type screen box, advanced structure, strong and durable Vibration exciter with eccentric shaft and eccentric block, high screening efficiency, large capacity

more+

Jaw Crusher

Xinhai improves the traditional specification of crushing chamber by adopting high speed swing jaw and cambered jaw plate.

more+

Hammer Crusher

High-speed hammer impacts materials to crush materials. There are two ways of crushing (Wet and dry)

more+

Jig

The cone slide valve is adopted; the failure rate is reduced by 80%; low energy consumption;the separation of different material, improvement of the processing capacity by more than 35%.

more+

Energy Saving Ball Mill

Cylindrical energy saving grid ball mill is lined grooved ring plate which increases the contact surface of ball and ore and strengthens the grinding.

more+

Cylinder Energy-Saving Overflow Ball Mill

20-30%. Rolling bearings replace slipping bearings to reduce friction; easy to start; energy saving 20-30%

more+

SF Flotation Cell

Both sides of the impeller with back rake blades ensures double circulating of slurry inside the flotation tank. Forward type tank, small dead end, fast foam movement

more+

LEACHING-OF-A-ROASTED-COPPER-SULFIDE-ORE.pdf Copper

This can be done by giving the sulphide ore an oxidizing-sulphatizing roast. Copper sulphate is soluble in water, so acid will be saved in the leaching process if

more+

Recovery of Copper from Copper Sulfide Concentrate by Sulfation

Feb 11, 2015 Sulfation Roasting, Copper Sulfide Concentrate, Copper Extraction. 1. most viable and promising approach to treat copper sulfide ore in metallurgy fields. In the present work, a sulfation roasting-acid leaching process that

more+

[Solved] What is the best method for sulfide copper leaching?

One of the important subject in copper sulfide leaching, Ore Characterisation and of the atmosphere pressure leaching, the CuS should be roasted before le.

more+

Roasting metallurgy - Wikipedia

Roasting is a process of heating of sulfide ore to a high temperature in presence of air. Sulfating roasting oxidizes certain sulfide ores to sulfates in a controlled supply of air to enable leaching of the sulfate for further processing.

more+

High temperature roasting of sulphide concentrate and its - Core

roast-leach route. The behaviour of individual sulphide minerals can aid in the understanding of selective leaching of a zinc-copper sulphide ore where pyrite

more+

A Review on Novel Techniques for Chalcopyrite Ore Processing

Jan 1, 2012 abundant of copper sulfides, but also the most stable . extractive metallurgy or leaching. Roasted before hydrometallurgical processing.

more+

Roasting of Sulfide Minerals - Wiley Online Library

economical. Furthermore, from most sulfide minerals the metal value is not brought chalcopyrite, the major source of copper is not leached. Commercially

more+

Treatment of a refractory gold—copper sulfide concentrate by

Pre-treating ore by ultra fine milling followed by thiosulfate leaching resulted in 94% gold and 60% silver recovery after 48 hours. Thiosulfate leaching of roasted

more+

Copper Mining and Extraction Sulfide Ores

The main ores of copper are sulfides and oxides. Advantages of this process are: See for further information on the leaching process. The roasting process:.

more+

Hydrogen Sulfide Production From Copper Concentrates - epa nepis

15 2 Equipment for Leaching Neutral-Roasted Concentrates in Hydrochloric Acid 23 3 . However, it is also understood that all but a very few copper sulfide ore

more+

The lime-concentrate-pellet roast process for treating copper sulfide

during a subsequent copper leaching. The 2-Cross-section of a -112 + 38-in. diameter pellet roasted! 30 minutes and other copper sulfide minerals while si-.

more+

Extraction of metals from complex sulfide nickel concentrates by low

Apr 11, 2017 The recovery of valuable metals from complex sulfide concentrates was investigated The roasted products and leach residues were characterized by X-ray approach for extracting multiple metals from complex concentrates or ores. . of the chlorination of iron, cobalt, nickel and copper sulphides, Can.

more+

Sulphating roasting of copper-cobalt concentrates

At that time, the roasting of metal sulphides was already one of the main leaching kinetics and to recover also the small portion of copper oxides that are

more+

Copper metallurgy at the crossroads - doiSerbia

Jul 14, 2007 and as a result, the roast reaction was displaced by the conversion reaction. . copper sulfide minerals in being the most resistant to leaching

more+

Roasting in Metallurgy

Mar 18, 2017 The roasting of these sulphides presents a good case for the study of the lower sulphides remaining are slowly oxidised, the copper sulphide being . to leach the roasted ore with water, before treating it with chlorine gas,

more+

Sulphation roasting and leaching of a low-grade copper ore from

When some sulphide minerals are roasted in air under care- fully controlled copper recoveries from leaching were investigated. Experimental. Material.

more+

Leaching of a gold bearing partially roasted sulphide. Laboratory

Oct 12, 2001 Mineralogical identification of the ore and diagnostic leaching are alternative . In the partially roasted sulphides bearing ore, gold was observed by promote a visible increase in copper, gold and iron concentrations;.

more+

Sulfate Roasting of Copper ORES and Economic Recovery of

Abstract. A cyclic copper leaching and recovery process is described. Laboratory tests on Rhodesian ores show that the roasting of copper ores should be

more+

IMPROVED ROASTING OF SOME COLOMBIAN GOLD ORES

ABSTRACT: This article shows the main results after roasting a gold ore with . some secondary copper sulfides, adsorbs the leaching solution leach-robbers,

more+

Methods of Processing of the Gold-Containing Refractory Sulfide

ABSTRACT. Alternative methods of processing the refractory gold-sulfide ores and concentrates quartzites, copper-zinc, antimonite were used in the research. As a result of . leaching without pre-acid treatment of the roasted product with a

more+

Copper sulfide ore value chain - Outotec

Using our partial roasting process, impurities like as arsenic and antimony can be copper concentrates with pyrometallurgical or hydrometallurgical means is

more+

Laboratory-scale sulphation roasting testwork for copper - Mintek

copper occur primarily as sulphates which are subsequently leached, while iron The sulphation roasting of cobalt and copper sulphides and oxides can be

more+

copper processing Definition, History, & Facts Britannica.com

The smelting and converting of copper sulfide concentrates result in a . The second step, involving either smelting or leaching, removes a large is first roasted in a cylindrical, refractory-lined furnace of either the hearth or fluidized-bed type.

more+

Effect of Pretreatment on Leaching Primary Copper Sulfide in - MDPI

Dec 21, 2017 Using reactor leaching, an 85% copper dissolution was obtained using as an alternative to conventional processes like roasting or chemical leached copper sulfide ore mainly containing chalcopyrite CuFeS2 and

more+

The roasting and leaching of Witwatersrand pyrite - SAIMM

from oxides or sulphides to water-soluble sulphates. For example, sulphation roasting has become an industrial reality in Katangal where a copper cobalt.

more+

Recovery of copper from smelting slag by sulphation roasting and

Jul 7, 2015 Keywords: copper, slag, sulphation, roasting, acid baking, leaching. Introduction . Among the copper sulphide minerals, the most abundant

more+

US5254320A - Method for roasting sulphide ores - Google Patents

A method for roasting sulphide ores or ore concentrates containing precious ore with subsequent leaching with cyanide, and--roasting of copper ore with a first

more+

Recovery of Cu and Zn from Complex Sulphide Ore - IOPscience

In the present work, leaching of complex sulfide ores in sulfuric As Zinc and copper often occur together, the separation of one metal from the other has The sulphur oxidation processes include roasting, pressure oxidation, chemical.

more+

evaluating process options for treating some refractory ores

solution within sulphide minerals pyrite and arsenopyrite FeAsS. leaching to the aggressive conditions found in pressure oxidation. Copper Sulphides. -. 0.15 .. With the high arsenic content in the feed concentrate for Ore A the roasting

more+

Evaluation of Refractory Behaviour of Kaletaş Turkey Gold Ore

in cyanide leaching The refractoriness of gold ores and base metal sulfides of lead, copper and zinc . 3.2 Cyanide Leaching after Roasting of the Ore.

more+

The reasons of gold refractory, Gold ore classification, and

Nov 28, 2016 If there is sulfide in the gold ore, the dissolution of gold will receive the Tellurium copper and gold mine, solid solution electrum, and some other alloy, in the cyanide solution, make ore difficult to cyanide and leach. Generally, we use roasting and chlorination pretreatment to destroy all or part carbon.

more+

REDUCTION LEACHING OF CHALCOPYRITE - Open Collections

reduction leach methods for chalcopyrite CuFeS2 copper con- . Process with Partial Roasting copper sulphides to liquid metallic copper in a crude 98.5-.

more+

Chlorine-Oxygen Leaching of a Low-Grade Zinc Sulfide Flotation

Chlorine·oxygen leaching ot a I ow, grade zinc sulfide flotation concentrate. . Effect of reactor operating pressure on zinc and copper extraction ••••••••• from complex fine-grained sulfide ores is substantially higher in low- during roasting.

more+

EP2829516A1 - Production method for hematite for iron production

C22B322 Treatment or purification of solutions, e.g. obtained by leaching by . of ores such as nickel sulfide ore, copper sulfide ore, and copper oxide ore, . is refined by roasting the leach residue and evaporating the sulfur component.

more+

Patents - Process Research Ortech Inc.

OF ROASTED METAL SULPHIDE ORES AND FERRITES BY LEACHING WITH 25, 1091036, ROAST-REDUCTIVE LEACH PROCESS FOR COPPER

more+

Copper - Department of Energy

Modern copper smelters generally have abandoned roasting as a separate step . method refers to the leaching of oxide and low-grade sulfide ore on typically

more+

Copper and cobalt recovery from pyrite ashes of a sulphuric acid plant.

Mar 17, 2016 Copper and cobalt recovery from pyrite ashes of a sulphuric acid plant. of concentrated pyrite ore used for producing sulphuric acid not only roasting method has an effect on the leaching efficiencies of copper Industrial Waste; Solvents; Sulfides; Sulfuric Acids; pyrite; Cobalt; Copper; Iron; sulfuric acid.

more+

Electrorefining Electrolyte from Copper Plant Dust

Keywords: copper dust, leaching, roasting, electrorefining. 1. Introduction ing roasting copper and iron sulphides are converted to their sulphates and oxides

more+

Ore Processing - Nevada Bureau of Mines and Geology - University

Metals are taken from the rocks of an ore deposit using chemistry. patios or "arrastras," water, mercury, salt and roasted copper and iron sulfides were added. . Copper is leached from finely ground rock and recovered by reduction on iron

more+

Pretreatment Process on Refractory Gold Ores with As - J-Stage

These options include: roasting oxidation; wet chemical treatment; bacterial The process of crushing or decomposition before gold leaching is called pretreatment of refractory gold. . Sulfur and arsenic removal separates gold and sulfide fully. .. to recovery copper from the low-grade copper ore or marginal copper ore.

more+

PRE Post:automatic aggregate crushing machine for sale gold supplier
NEXT Post:gravity centrifugal concetrator

1993-2018 Xinhai Machine . All rights reserved | Design by Xinhai